In the last few weeks, I have discovered a hairline crack in the ceiling above our living room. Its now about 2-3 in length. It is extending from casing holding fluorescent lights over the kitchen. I have read online regarding this and have seen a few different causes of it. I was hoping to get a permanent fix to this and not a cover up job. Homes with vaulted ceilings may develop these cracks in the higher areas as well. Additionally, drywall cracks are often found where two pieces of drywall are butted together. This occurs because there is a joint, which gets drywall taped and then layered with two or three coats of drywall mud.

Hairline Cracks In Ceiling Uk
Hairline Cracks In Ceiling New House
How To Fix Hairline Cracks In Ceiling Paint
Hairline Cracks In Ceiling Drywall

Do you have cracks in your ceiling? Find out if the cause is simply cosmetic, of if you're facing a structural issue that needs immediate attention.

Photo: istockphoto.com

Q: I just noticed a crack in my ceiling, but I’m not sure how long it’s been there. Is it a normal symptom of an aging house? Or is it an indication that something is dangerously wrong? Should I be worried?

A: Over time, virtually all homes will develop cracks that are cosmetic in nature and not indicative of a larger problem. But some cracks—especially those wider than 1/8-inch—may signal structural issues. Examining the shape, size, and location of the crevice can give insight into possible causes and solutions. Here’s how to deal with cracks in the ceiling, whether they appear in the bedroom, kitchen, basement, or other room of the house.

Causes of Ceiling Cracks—and How to Fix Them

A fine straight ceiling crack could be the result of a poorly taped joint.

If an insufficient amount of drywall mud was used during the taping process, the paper tape won’t adhere well to the joint. As a result, you may notice a straight “crack” along the edge of loosened tape.

Solution: Homeowners can choose to ignore this superficial problem, since it isn’t a structural or safety hazard. You can also minimize the appearance of the crack by applying a small amount of thin drywall compound under the loose tape and re-adhering it to the drywall.

A discolored crack indicates a moisture problem.

Sometimes, water from an overhead leak can trickle between the ceiling’s drywall panels, causing the joint tape to loosen, creating the appearance of a crack, and leaving unsightly yellow or brown stains. Before you can repair the ceiling, determine the cause of the leak and fix it.

Solution: To undo the damage done to the ceiling, scrape off the loose tape and re-tape the joint, either with a drywall repair kit or paper tape and joint compound. If you have a textured ceiling, use an aerosol texture product (found in home improvement stores) to cover the newly re-taped joint so it blends into the ceiling’s existing texture.

Note: Drywall will resist some moisture, but long-term leaks can result in water damage, which requires replacement of the damaged drywall. If the drywall has swollen or softened, it’s no longer viable; the damaged section must be replaced before re-taping and re-texturing.

Photo: istockphoto.com

Induction Motor Rewinding Calculation. 6/26/2019 0 Comments How to find number of winding turns for a three phase induction motor. To calculate the wire size, you would calculate the maximum size would fit in the slots. Then calculate the stator copper loss. If the copper loss is too high, select a winding distribution that is more efficient. The calculation will be performed for the air-cooled, three-phase motors for continuous duty cycle S1, standard efficiency, 50 or 60 Hz, SF 1.00, lap or concentric, single or double-layer, for the maximum power from the given iron core. Please, carefully review the information needed, and be aware that more details gives more accurate results. The wire-size can be calculated in several different ways (the area of an old winding or a slot of a other shape or the cross section of all wires, etc. A 480-V, 60 Hz, 50-hp, three phase induction motor is drawing 60 A at 0.85 PF lagging. The stator copper losses are 2 kW, and the rotor copper losses are 700 W. Induction motor winding calculation.

Tiny spiderweb cracks may suggest thick application of drywall compound.

Thinned drywall compound is often used to create a textured ceiling. If it was applied too thickly, you may notice tiny cracks that run in all directions because the compound shrinks as it dries.

Solution: To conceal the blemishes, try applying a thin layer of drywall compound over the existing texture. You could also remove the existing texture by sanding—a messier prospect—and apply new drywall compound to the ceiling.

Truss uplift can cause a horizontal crack between an interior wall and the ceiling.

Roof trusses are designed to move slightly as their wood members expand and contract with attic temperature and moisture fluctuations. When the roof truss pulls upward, it may lift the ceiling drywall along with it, creating a crack between the wall and the ceiling. This common mistake often occurs if a handyman attaches drywall panels to the trusses near the edge of a non-load bearing wall.

Hairline Cracks In Ceiling Uk

Solution:The only way to permanently fix the issue is removing the nails or screws that secure the edge of the drywall panels to the trusses, and reattaching them to clips or blocks installed on the top of the interior wall plates. It’s best to hire a professional for this project.

If a homeowner doesn’t care to repair the issue, they can camouflage the crack by installing dark-stained crown molding around the top of the room. The molding should be attached only to the framing members in the wall—not to the ceiling joists. This cosmetic ceiling repair won’t stop the trusses (and the ceiling drywall) from lifting with moisture and temperature changes, but the dark color of the molding will disguise the appearance of the crack, while also adding a decorative touch to the room.

Ceiling cracks accompanied by wall cracks could be the result of the house settling.

Homes naturally settle as they age, which can create crevices in the walls and ceilings typically above doors and windows as well as in corners. These superficial hairline cracks can usually be re-taped—but, if the house continues to settle, the cracks are likely to reappear in the same spots.

Solution: If the gaps are wider than 1/8-inch, it’s a good idea to consult a reputable home builder, since you may have a structural problem.

In older homes with plaster ceilings, movement and moisture may create cracks.

Hairline Cracks In Ceiling New House

Since plaster is extremely rigid, the slightest movement can cause a gap. Typically, plaster ceiling cracks have two causes: house settling and temperature or moisture fluctuations in an attic, which result in the expansion or contraction of framing members. Download sean price mic tyson deluxe edition free.

Solution: Homeowners can fill these commonly occurring hairline cracks with new plaster and repaint the ceiling. If you have wider cracks or sections of loose plaster, the lath system beneath the plaster is likely failing—in which case, the plaster should be removed and replaced with drywall.

Large cracks on a bowed ceiling could indicate a structural problem.

How To Fix Hairline Cracks In Ceiling Paint

When a ceiling bows or sags, you have a problem that requires prompt attention. If you’ve recently installed something heavy on the floor above—such as a hot tub, a waterbed, or a pool table—the ceiling joists might sag under the excessive weight. A ceiling may also crack or bow du